Volkswagen Golf Service & Repair Manual: Safety precautions when working on the cooling system
| Risk of scalding by hot coolant |
| When the engine is warm, the cooling system is under pressure. Danger of scalding due to steam and hot coolant. |
| – | Always wear safety gloves. |
| – | Always wear safety goggles. |
| – | Proceed as follows to release the pressure: cover the cap of the coolant expansion tank with a cloth, and open it carefully. |
Safety precautions when working in the vicinity of high-voltage components
Danger to life due to high voltage
The high-voltage system is under high voltage. If high-voltage
components are damaged, there is a risk of severe or fatal injury due to
e ...
Safety precautions for working on vehicles with auxiliary/supplementary
heater
Danger of fire and explosion from auxiliary/supplementary heater
In fire and explosion-endangered areas a spark or the high
temperature of the auxiliary/supplementary heater ca ...
Other materials:
Removing and installing headlight range control unit -J431-/control unit for
cornering light and headlight range control -J745-, RHD vehicles
Note
When renewing the control unit, select
Renew function for the respective control unit in
Guided fault finding or
Guided functions mode
→ Vehicle
diagnostic tester.
Removing
â ...
Removing and installing water deflector
Note
Removal and installation are described only for the left side.
Removal and installation of the right side are similar.
Removing
–
Starting at bottom end, pull water deflector
-1- out of clip -3- and retaining
strip -2-.
...
Overview of fitting locations - mobile online services
1 -
Radio/RNS -RX1-
2 -
Telephone microphone -R38-
Installed in front section of roof console
Removing and installing
→ Chapter
3 -
Control unit 1 for information electro ...
