VW Golf manuals

Volkswagen Golf Service & Repair Manual: Safety precautions when working in the vicinity of high-voltage components

Volkswagen Golf Service & Repair Manual / Heating, air conditioning / Technical data / Safety instructions / Safety precautions when working in the vicinity of high-voltage components

Danger to life due to high voltage
The high-voltage system is under high voltage. If high-voltage components are damaged, there is a risk of severe or fatal injury due to electric shock.
–  Perform visual check of high-voltage components and high-voltage cables.
–  Never use cutting or forming tools, or any other sharp-edged tools.
–  Never use heat sources such as welding, brazing, soldering, hot air or thermal bonding equipment.
 
Safety precautions when working on high-voltage system
Danger to life due to high voltage The high-voltage system is under high voltage. There is a risk of severe or fatal injury due to electric shock. –  Pe ...

Safety precautions when working on the cooling system
Risk of scalding by hot coolant When the engine is warm, the cooling system is under pressure. Danger of scalding due to steam and hot coolant. –  Alway ...

Other materials:

Introduction
This chapter contains information on the following subjects:  → Stowage  → Contents Observe any country-specific legislation when securing your vehicle in the event of a breakdown. Additional information and warnings: Preparation for working in the engine compartment ...

Identification of Denso heater and air conditioning unit
  Note Pay attention to correct assignment when replacing components. The combination of different makes of component is not permitted → Electronic Parts Catalogue. –  Remove left centre console trim ...

Removing and installing rear treble loudspeakers -R14-/-R16-, 2-door
Rear left treble loudspeakers -R14-/rear right treble loudspeakers -R16- are located in rear side trim panels.   Note If the treble loudspeaker must be renewed, the loudspeaker grille must also be renewed. ...

© 2016-2022 Copyright www.vwgolf.org