VW Golf manuals

Volkswagen Golf Service & Repair Manual: Hose repair

A new repair concept has been developed for repair work on wash system hoses. Various connectors, special EPDM hoses (ethylene-propylene terpolymer) and heat-shrink hose are available as spare parts.
   
General description
The replacement parts can be found in the electronic parts catalogue (ETKA).
Replacement parts are available for repair of both smooth and corrugated pipes.
   
Headlight washer system
–  To loosen the connection, push the lock ring -1--arrow- and pull off the hose connection. –  To secure the connecti ...

Repairing smooth pipe
Smooth pipe with a diameter or 5x1 mm or 6x1 mm can be repaired with EPDM hose. –  Cut damaged section at right angles out of ...

Other materials:

Removing and installing storage compartment
Special tools and workshop equipment required       Torque wrench -V.A.G 1783- Removing –  Unbolt front seat and tilt it towards rear. Do not remove ...

Run-flat tyres, PAX, inflating tyre
Observe the following important points when inflating the tyre: –  Only inflate after fitting the tyre with valve core installed. Check whether the beads have properly seated at 1 bar. –  ...

Removing and installing air distribution flap control motor -V428-, LHD vehicles
Special tools and workshop equipment required Vehicle diagnostic tester Removing –  Remove dash panel → General body repairs, interior; Rep. gr.70. ...

© 2016-2023 Copyright www.vwgolf.org