VW Golf manuals

Volkswagen Golf Service & Repair Manual: Engine lubrication

Valve dimensions
  Note     Inlet and exhaust valves must not be reworked. Only lapping-in is permitted.   ...

Sump, oil pump
...

Other materials:

Vehicles with torsion beam axle
The connecting pipe can be cut through at the cutting point in order to renew the centre and rear silencers separately. Cutting point is marked by an indentation on circumference of exhaust pipe. Special tools and ...

Changing headlights over from driving on left to driving on right (gas discharge headlights)
If a right-hand drive vehicle is driven in a left-hand drive country, or vice versa, the headlights must be converted. This is necessary in order to avoid dazzling oncoming traffic with the asymmetric low beam headlights.   Note ...

Removing and installing relay and fuse carrier behind dash panel, RHD vehicles
Removing –  With ignition switched off, disconnect earth cable from battery → Chapter. –  Remove dash panel → General body repairs, interior; Rep. gr.70. ...

© 2016-2026 Copyright www.vwgolf.org