Volkswagen Golf Service & Repair Manual: Maintaining records on refrigerant

Volkswagen Golf Service & Repair Manual / Air conditioning system with refrigerant R134a / Statutory texts and instructions / Maintaining records on refrigerant

Note

The laws and regulations listed below are valid in the Federal Republic of Germany. Other or additional laws and regulations may apply in other countries.

Sources in other countries may be obtained from the responsible authorities.

The quantities used during operation and maintenance work should be documented (see Refrigerant Logbook, → Volkswagen ServiceNet, Environmental Protection; Service handbook; Emission protection; Air contaminating substances, refrigerant for vehicle air conditioning systems) or proof of use document which must be available for presentation to the responsible authorities upon request. A record sheet need no longer be kept within the EU due to respective European parliament legislation from 2005. Other legislation may apply in countries not belonging to the EU.

Converting R12 refrigerant circuits to R134a refrigerant circuits and repairing them (retrofitting)

Note The laws and regulations listed below are valid in the Federal Republic of Germany. Other or additional laws and regulations may apply in ot ...

Refrigerant circuit

...

Other materials:

Removing and installing knock sensor 1 -G61
Removing – Remove air conditioner compressor from bracket and tie up → Heating, air conditioning; Rep. gr.87. – Disconnect electrical connector ...

Winter tyres
First read and observe the introductory information and safety warnings In winter road conditions, winter tyres will considerably improve the car's handling. The design of summer tyres (width, rubber compound, tread pattern) gives less grip on ice and snow. Volkswagen urgently recommends ...

Balancing wheel, checking radial and lateral run-out of wheels and tyres
Before you start balancing the wheels, the following requirements must be met. Tyre pressure must be OK. Tread must not be worn on one side. Tread depth should be at least 4 mm. T ...