Volkswagen Golf Service & Repair Manual: Assembly overview - sump and oil pump
Note
Metal shavings or a large quantity of small metal particles found
during engine repair could indicate that the crankshaft bearings or
conrod bearings are damaged. To avoid any subsequent damage, the
following work must be carried out following the repair: Carefully clean
oil channels and renew oil spray jets, engine oil cooler and oil filter. |
Removing and installing oil spray jets
→ Chapter. |
2 - |
Oil level and oil temperature sender -G266- |
Removing and installing
→ Chapter |
Note
The oil drain plug only has to be replaced if it has a permanent
seal. |
Removing and installing
→ Chapter |
For oil pump drive sprocket |
Before removing, mark running direction with paint. |
Specified torque and tightening sequence
→ Fig. |
Removing and installing
→ Chapter |
Remove and install with oil filter tool -3417-. |
Before installing, lightly coat seal with clean engine oil. |
Removing and installing
→ Chapter |
Tightening sequence → Fig. |
Lower part of sump - specified torque and tightening
sequence |
– |
Tighten bolts in stages in the sequence shown: |
|
|
|
Stage |
Bolts |
Specified torque |
1 |
-1 … 19- |
Screw in to contact by hand |
2 |
-1 … 19- |
12 Nm |
Upper part of sump - specified torque and tightening
sequence |
Note
Renew bolts that are tightened with specified tightening
angle. |
– |
Tighten bolts in stages in the sequence shown: |
|
|
|
Stage |
Bolts |
Specified torque/
additional specified angle |
1 |
-1 … 19- |
Screw in to contact by
hand |
1 |
-1 … 19- |
8 Nm |
2 |
-1 … 19- |
Turn 90° further |
Removing
–
Drain off engine oil.
–
Disconnect electrical connect ...
Other materials:
Checking fuel delivery rate
Special tools and workshop equipment required
Removal wedge -3409-
Remote control for V.A.G. 1348 -V.A.G 1348/3A-
Multimeter e.g. hand-held multimeter -V.A.G 1526E-
Test instrument adapter/DSO (5-pin) -VAS 5565-
...
Checking auxiliary air heater element -Z35- with auxiliary air heater
control unit -J604-, LHD vehicles
Checking
Special tools and workshop equipment
required
Vehicle diagnostic tester with current probe 100 A -VAS
5051B/7-
Test conditions
Intake temperature less th ...
Introduction
This chapter contains information on the following subjects:
→ Opening or closing the windows electrically  
→ Electric windows – functions  
→ Roll-back function for the electric windows  
Additional information and warnings:
Volkswagen information system â ...
© 2016-2024 Copyright www.vwgolf.org