Volkswagen Golf Service & Repair Manual: Testing quantity of fuel delivered
Note
Check fuel delivery rate as described in “Guided Fault
Finding” function, vehicle diagnostic tester in “Guided Fault
Finding” mode. |
Conditions for checking fuel delivery rate (in short): |
Coolant temperature below 30 °C |
Ambient temperature below 25 °C |
Fuel tank sufficiently filled (needle on fuel gauge in dash
panel insert is not in red zone) |
Battery -A- (vehicle battery) fully charged |
Fuel line (from fuel tank to auxiliary heater) installed
according to specifications and filled completely with fuel |
Auxiliary heater installed completely and connected to
vehicle electrical system |
All auxiliary heater fuses OK (according to current flow
diagram) → Current
flow diagrams, Electrical fault finding and Fitting locations |
Auxiliary heater is switched off |
Event memory of all self-diagnosis compatible systems read
out; cause of any faults displayed in vehicle systems
eliminated; displayed event memory entries erased, vehicle
diagnostic tester in "Guided Fault Finding". |
Note
A higher ambient or coolant temperature can lead to
incorrect measurements of the fuel quantity delivered due to
fuel evaporation. |
Complete description of conditions for checking fuel
delivery rate vehicle diagnostic tester in “Guided Fault
Finding” mode. |
If the quantity of fuel delivered is in the lower tolerance
range and there are starting difficulties with the auxiliary
heater, check the fuel lines to the auxiliary heater
→ Chapter. If no fault is found, renew the metering
pump -V54-
→ Chapter. |
– |
Check fuel delivery rate of metering pump -V54-vehicle
diagnostic tester in “Guided Fault Finding” mode. |
|
|
|
Note
Fuel lines are secured with O-type clips. These O-type clips
must always be renewed every time they are removed.
Star ...
Note
Pay attention to correct part number of metering pump -V54-
(different versions)
→ Electronic Parts Catalogue.
R ...
Other materials:
Rear brakes
The type of brake system installed in the vehicle is
indicated among other things by the corresponding PR number on
the vehicle data sticker.
The vehicle data sticker can be found in the spare wheel
well and in the service schedule.
...
Stowage compartment in the front centre console
Fig. 111 In the centre console: stowage
compartment
First read and observe the introductory information
and safety warnings To open, briefly press the cover of the stowage
compartment (arrow).
To close, push the stowage compartment cover down as far as it will go.
The stowage co ...
Assembly overview - rear seat backrest cover and padding
1 -
Backrest cover
Different equipment versions
Allocation
→ Electronic Parts Catalogue
Removing and installing backrest cover with backrest padding
→ Chapter
Separating backrest cover from backrest padding
→ Chapter
...
© 2016-2024 Copyright www.vwgolf.org