Volkswagen Golf Service & Repair Manual: Reservoir
| The reservoir collects the vaporised and gaseous mixture
coming from the evaporator to ensure the air conditioner
compressor receives only gaseous refrigerant. Gaseous
refrigerant is formed from the vapour. |
| Refrigerant oil flowing in the circuit does not remain in
the reservoir, as an oil extraction hole has been provided. |
| Moisture which has entered the refrigerant circuit during
repairs will be collected by a filter (dessicant bag) in the
reservoir. |
| Gaseous refrigerant with oil is drawn in by the air
conditioner compressor. |
 Note
| Renew the reservoir if the refrigerant circuit has stood
open for any length of time (more than the normal repair time)
and moisture has entered the system, or if it is required
because of a specific complaint
→ Chapter. |
| Do not remove sealing plugs -A-
and -B- until just before
installation. |
| The dessicant bag in an unsealed reservoir will become
saturated with moisture within a short time and is then
unusable. |
| When installing, observe arrow indicating direction of flow,
if applicable. |
|
|
|
The liquid refrigerant evaporates in the tubes of the
evaporator. The latent heat of evaporation is taken from the air
streaming past the evaporator fins. The air coo ...
The restrictor creates a restriction. This restriction
limits the flow, separating the high-pressure and low-pressure
sides in the refrigerant circuit. Upstream of th ...
Other materials:
Contact surface cleaning set -VAS 6410-
Using contact surface cleaning set -VAS 6410-
The contact surface cleaning set -VAS 6410- allows optimal
repair quality to be achieved in the area of vehicle electrics.
The tools allow performing repair work in the area of the sensor
in wiring harnesses for t ...
Removing and installing mounting bracket, LHD vehicles
Remove dash panel end cover on driver side
→ General body repairs, interior; Rep. gr.70.
–
Remove footwell cover on driver side
→ General body repairs, interior; Rep. gr.68.
â ...
Removing and installing refrigerant circuit pressure sender -G805
Special tools and workshop equipment
required
Torque wrench -V.A.G 1331-
Commercially available twelve-point socket bit, extra long,
1/2", 24 mm (dimensions: 32x82 ...
© 2016-2026 Copyright www.vwgolf.org
Evaporator
Restrictor