Volkswagen Golf Service & Repair Manual: Repairing steering rack
| 1 - | Right track rod ball joint |
| Marked with “A” → Anchor |
| Removing and installing → Chapter |
| Installation position → Anchor |
| Allocation → Electronic Parts Catalogue “ETKA”. |
| 2 - | Nut |
| Counterhold on track rod ball joint with a spanner when loosening or tightening nut. |
| 70 Nm |
| 3 - | Clamp |
| 4 - | Boot |
| Must not be twisted after toe setting has been adjusted. |
| Removing and installing → Chapter |
| 5 - | Clamp |
| Renew |
| Tightening → Anchor |
| 6 - | Track rod |
| Removing and installing → Chapter |
| 100 Nm |
| 7 - | Steering rack |
| Allocation → Electronic Parts Catalogue “ETKA”. |
| Removing and installing → Chapter |
| 8 - | Left track rod ball joint |
| Marked with “B” → Anchor |
| Removing and installing → Chapter |
| Installation position → Anchor |
| Allocation → Electronic Parts Catalogue “ETKA”. |
| 9 - | Nut |
| Counterhold on track rod ball joint with a spanner when loosening or tightening nut. |
| 70 Nm |
| 10 - | Spring-type clip |
| 11 - | Boot |
| Removing and installing → Chapter |
| Check for damage |
| Must not be twisted after toe setting has been adjusted. |
| 12 - | Clamp |
| Renew after removing |
| Secure new hose clip using locking pliers for Phaeton steering rack -VAS 6199-. |
| 13 - | Track rod |
| If defective, renew together with track rod ball joint |
| Removing and installing → Chapter |
| 100 Nm |
Removing and installing track rod ball joint
Special tools and workshop equipment
required
Ball joint puller -T10187-
...
Sensors
Removing and installing steering angle
sender -G85-
Note
The steering angle sender -G85- is a component of the ...
Other materials:
Removing and installing control unit for daytime running light and side
light -J860-/-J861-
WARNING
Risk of death due to high voltage! Risk of injury
and environmental pollution!
Observe operation and safety notes for gas discharge
bulbs
→ Chapte ...
Dealing with problems with Midtronics -INC 940- battery tester
Under certain circumstances, the display may show errors or
messages according to status.
The most frequent display messages are listed below,
together with suggested solutions.
Note
For messages not liste ...
Adjusting spray jets
Caution
Danger of causing damage.
Do not use any objects for cleaning spray jets!
Note
In case of uneven spray field due to impurities in th ...
