Volkswagen Golf Service & Repair Manual: Repairing corrugated pipe
Special tools and workshop equipment
required |
|
|
|
Hot air blower -VAS 5179- or |
Hot air blower -V.A.G 1416/- or |
Hot air blower -VAS 1978/14- |
Note
Repair points must not be subjected to pulling or bending
forces. |
If the damaged section is longer than 20 mm, a new piece of
corrugated pipe must be used and the procedure described below
must be performed twice. |
|
|
|
– |
Cut damaged section at right angles out of corrugated pipe
which is to be repaired. |
– |
Select suitable end pieces -2-
and -3- and correct sized
shrink-fit piping from the electronic parts catalogue (ETKA). |
– |
Heat end of corrugated pipe -1-. |
– |
Push connector -2- into
corrugated pipe -2--arrow A-. |
– |
Heat end of corrugated pipe -4-. |
– |
Push connector -3- into
corrugated pipe -4--arrow B-. |
|
|
|
– |
Cut heat-shrink hose so that ends of corrugated pipe are
each covered by about 20 mm -dimension x-
of heat-shrink hose. |
– |
Push heat-shrink hose over corrugated pipe, join connectors
and secure repair joints with heat-shrink hose. |
|
|
|
Smooth pipe with a diameter or 5x1 mm or 6x1 mm can be
repaired with EPDM hose.
–
Cut damaged section at right angles out of ...
Distinguishing features of Bosch and Federal Mogul products.
When renewing wiper rubbers, note the make. When renewing
wiper blades, the same ...
Other materials:
Removing and installing door
Special tools and workshop equipment
required
Door alignment tool -3320-
Universal joint for 3320 -3320/1-
Bit for 3320 -3320/2-
...
Run-flat tyres, structure and identification of a SST tyre
Removing and fitting run-flat tyres
→ Chapter.
If run-flat tyres are used, a Tyre Pressure Monitor display
must be fitted.
Damage to the tyre and the resulting pressure loss cannot be
detected with the n ...
Removing and installing tail light
Note
Removal and installation are described for the left side.
Removal and installation on the right side are carried out in
the same way.
If the event of a defective LED, the entire tail light needs
to be rene ...
© 2016-2024 Copyright www.vwgolf.org