VW Golf manuals

Volkswagen Golf Service & Repair Manual: Renewing trim elements, bonded trim elements

Special tools and workshop equipment required
   
Cartridge gun -V.A.G 1628-
 

Renewing trim elements, bonded trim elements

Removal wedge -3409-
 

Renewing trim elements, bonded trim elements

Hot air blower -V.A.G 1416-
Materials
 

Renewing trim elements, bonded trim elements

1K Window adhesive
-DH 009 100 A2-
Silicone remover
-LSE 020 100 A3-
 
     
Removing trim element
  Note
The trim element cannot be removed without causing damage to the element.

Renewing trim elements, bonded trim elements

–  Remove clamping washers -2- on inner side of alloy wheel.
–  Heat outer side of trim element -1- with hot air blower -V.A.G 1416-.
  Caution
Use only low heat on tyres and alloy wheels (do not overheat).
–  Release trim element -1- on inner side of alloy wheel using wedge -3409-.
–  Grasp under a corner on the outside and pull trim element -1- forcefully off alloy wheel.
  Note
Cut back adhesive PUR beads on alloy wheel.
Residual material is used as a bonding base for the new trim element.
The new trim element can be installed immediately.

 
     
Installing trim element
These alloy wheels are fitted with exchangeable trim elements. Follow these instructions during installation.
Ensure bonding surfaces in alloy wheel and trim element are free of dust and grease.
Clean bonding surfaces with silicone remover -LSE 020 100 A3-.

Renewing trim elements, bonded trim elements

–  Apply 1K window adhesive -DH 009 100 A2- to bonding surfaces -arrows- using cartridge gun -V.A.G 1628-.
Adhesive bead: length = approx. 25 mm and diameter = approx. 10 mm.

 
     

Renewing trim elements, bonded trim elements

–  Push trim element -2- forcefully into alloy wheel -1-.
–  Secure trim element -2- on inner side of alloy wheel -3- with clamping washers.
Minimum curing period: 3 hours at a minimum room temperature of 15°C.
  WARNING
Alloy wheel must be rebalanced → Chapter.
Renewing trim elements
...

Renewing trim elements, bolted trim elements
These wheels are fitted with exchangeable trim elements. Follow these instructions during installation.     –&n ...

Other materials:

Removing and installing rear lid seal
In the factory a sealant is applied to the rear lid seal, the seal is fitted to the body flange and then rolled on. Note When the seal is removed, the sealant on the inside of the seal will be spread and the flanks will be bent out slightly. If the seal is then refitted, sealing and fir ...

Overview of fitting locations - front control motors, air conditioning system with electric/manual controls, RHD vehicles
1 -  Temperature flap control motor -V68- Checking: with vehicle diagnostic tester Removing and installing → Chapter. Renewing: initiate basic setting using vehicle diagnostic tester. 2 -&nb ...

Overview of fitting locations
Overview of fitting locations - ABS/ESP 1 -  ABS control unit -J104- Installation location: on hydraulic unit, on passenger side in engine compartment. Do not separate connector before successfully completing self-diagnosis. Switch ...

© 2016-2024 Copyright www.vwgolf.org