Volkswagen Golf Service & Repair Manual: Removing and installing windscreen washer pump
| Special tools and workshop equipment
required |
| – |
Remove front left wheel housing liner
→ General body repairs, exterior; Rep. gr.66. |
|
|
|
| – |
Disconnect electrical connector -1-. |
| Wiring harness -2- remains
connected to washer fluid reservoir. |
| – |
Place drip tray under washer fluid reservoir. |
| – |
Release securing clips -3- and
-4- in direction of arrow
-A-. |
| – |
Pull water line off washer pump -5-. |
| – |
Pull washer pump -5- upwards
-arrow B- out of washer fluid
reservoir. |
| Install in the reverse order of removal, observing the
following: |
 Note
| The connections at the pump and hoses are colour-marked to
prevent incorrect connection of the washer fluid lines to the
windscreen and rear window washer pump -V59-. The hose fittings
must be connected to the correct colour-coded pump connections
during installation. |
| – |
Check sealing grommet for damage. |
|
|
|
Special tools and workshop equipment
required
Drip tray
Note
Dependent on the equipment level, the windsc ...
Special tools and workshop equipment
required
Drip tray
Removing
–
Remove washer fl ...
Other materials:
Repairing lock carrier. Right headlight mounting
Note
Line -3- indicates the position
where the tab might break off.
–
Remove front bumper cover
→ Chapter.
–
Remove headlights
→ Electrical system; Rep. gr.94.
–
...
Assembly overview - B-pillar trim
Note
The illustration shows the B-pillar trims on the left side.
The right-hand side is similar (mirror image of left-hand side).
Upper part of B-pillar trim
I: Upper B-pillar trim, 4-door model
...
Assembly overview - lock carrier, NAR
1 -
Lock carrier with add-on parts
Removing and installing
→ Chapter
Moving to and back from service position
→ Chapter
2 -
Mounting plate
Left and right
3 -
Air guide
...
© 2016-2024 Copyright www.vwgolf.org
Removing and installing windscreen washer fluid level sender,
»R«
Removing and installing washer pump, »R«