Volkswagen Golf Service & Repair Manual: Removing and installing rear left vehicle level sender -G76-, torsion beam axle

Volkswagen Golf Service & Repair Manual / Running gear, axles, steering / Self- levelling air spring system / Vehicle level senders / Removing and installing rear left vehicle level sender -G76-, torsion beam axle

Special tools and workshop equipment required

Torque wrench -V.A.G 1410-

Removing

Removing and installing rear left vehicle level sender -G76-, torsion beam axle

–	Disconnect connector -1-.

–	Remove bolts -2- and -4-.

–	Remove rear left vehicle level sender -G76--3-.

Installing

Install in reverse order of removal, observing the following:

Note

The lever of the rear left vehicle level sender -G76- must face towards rear of vehicle.

Perform basic setting of wheel damper electronics → Vehicle diagnostic tester.

Carry out basic setting of headlights → Electrical system; Rep. gr.94.

Specified torques

→ Chapter „Assembly overview - rear vehicle level sender, torsion beam axle“

Removing and installing rear left vehicle level sender -G76-, torsion beam axle

Removing and installing front vehicle level senders -G78-/-G289-

Special tools and workshop equipment required Torque wrench -V.A.G 1410- Removin ...

Removing and installing rear left vehicle level sender -G76-, multi-link suspension, front-wheel drive

Special tools and workshop equipment required Torque wrench -V.A.G 1410- Removin ...

Other materials:

Renewing bonded rubber bush for wheel bearing housing, four-wheel drive
Special tools and workshop equipment required Assembly tool -3301- Viscous fan fitting tool -3367- Carrier -3390- Torque wrench -V.A.G 1332- Removing – ...

Wiring open circuit with one repair position
Repair position with single crimp connector – Place the wire to be repaired to one side (about 20 cm either side of the repair position). – If necessary, unbind the wir ...

Maintaining records on refrigerant
Note The laws and regulations listed below are valid in the Federal Republic of Germany. Other or additional laws and regulations may apply in other countries. Sources in other countries may be obtained from the ...