VW Golf manuals

Volkswagen Golf Service & Repair Manual: Removing and installing radiator fan -V7

Risk of hand injury caused by the radiator fan starting automatically.Do not grasp into the radiator fan when disconnecting the connector.
Removing
  Note
Reinstall all cable ties in the same locations when installing.
–  Remove radiator cowl → Chapter.
   
–  Separate electrical connectors.
–  Unscrew bolts -arrows- and remove radiator fan -V7-.
Installing
Installation is carried out in the reverse order; note the following:
–  Install radiator cowl → Chapter.
Specified torques
→ Chapter „Assembly overview - radiator cowl and radiator fan“
 

Removing and installing radiator fan -V7

Removing and installing radiator cowling
Removing –  Release hose clip -1- and detach air hose.     –  Un ...

Exhaust turbocharger, g-charger
...

Other materials:

Separating control unit from hydraulic unit
Special tools and workshop equipment required ESD workplace -VAS 6613- Torx bit T25 If a control unit is defective, separate it from the hydraulic unit and renew only the control ...

Stowage compartment in the front centre console
Fig. 111 In the centre console: stowage compartment First read and observe the introductory information and safety warnings To open, briefly press the cover of the stowage compartment   (arrow). To close, push the stowage compartment cover down as far as it will go. The stowage co ...

Removing and installing front vehicle level senders -G78-/-G289-
Special tools and workshop equipment required     Torque wrench -V.A.G 1410- Removing   –  Disconnect co ...

© 2016-2022 Copyright www.vwgolf.org