Volkswagen Golf Service & Repair Manual: Removing and installing pop-up cylinder, »R«
Special tools and workshop equipment
required |
Note
Removal and installation are described for the left side.
Removal and installation on the right side are carried out in
the same way. |
– |
Remove front part of right wheel housing liner
→ General body repairs, exterior; Rep. gr.66. |
– |
Place drip tray under washer fluid reservoir. |
– |
Release securing clip of water line. Pull water line off
headlight washer system pump -V11-, and unclip it from washer
fluid reservoir. |
– |
Collect washer fluid in drip tray. |
– |
Remove front bumper
→ General body repairs, exterior; Rep. gr.63. |
|
|
|
– |
Press release button -1- in
direction of arrow -A-. |
– |
Pull water hose -2- off pop-up
cylinder -3- in direction of arrow
-B-. |
|
|
|
– |
Working with compressed air, drive pop-up cylinder together
with cap -1- out of bumper cover
and hold it in place. |
– |
Press cap -1- on both sides out
of upper mountings -2- in direction
of arrow -A-. |
– |
Swing cap -1- in direction of
arrow -B- and unclip it from lower
mountings -3-. |
|
|
|
– |
Press release buttons -1- in
direction of arrow -A-. |
– |
Pull pop-up cylinder -2-
downwards out of mounting -3-. |
Install in the reverse order of removal, observing the
following: |
Note
Observe the markings distinguishing the pop-up cylinders for
left and right. |
Ensure that the pop-up cylinder engages audibly when being
pushed into the mounting. |
When connecting the washer fluid line, ensure that the
securing clip engages audibly in the connection. |
|
|
|
Special tools and workshop equipment
required
Drip tray
Removing
Note
Removal and ...
Removing
Note
Removal and installation are described for the left side.
Removal and installation on the right side are carried out in ...
Other materials:
Warning lamp
First read and observe the introductory information
and safety warnings
Display
Possible cause
Solution
The tailgate is open or not properly closed.
Do not drive
on!
Open the tailgate and then close it again.
Sev ...
Removing and installing high-level brake light, GTI, GTD and
»R«
Removing:
–
Remove roof spoiler
→ General body repairs, exterior; Rep. gr.66.
–
Unscrew bolts -1-,
-5- and -6-
from high-level brak ...
Statutes and regulations
Note
The laws and regulations listed below are valid in the
Federal Republic of Germany. Other or additional laws and
regulations may apply in other countries.
Sources in other countries may be obtained from the
...
© 2016-2024 Copyright www.vwgolf.org