Volkswagen Golf Service & Repair Manual: Removing and installing pistons

Volkswagen Golf Service & Repair Manual / 4- cylinder injection engine(1.4 1 direct inction. turbocharger) / Enginecrankshaft group, pistons / Pistons and conrods / Removing and installing pistons

Special tools and workshop equipment required

Drift -VW 222 A-

Piston ring clamp, commercially available

Removing

–	Removing cylinder head → Chapter

–	Remove sump upper part → Chapter.

–	Mark piston installation position and corresponding cylinder number.

–	Mark installation position and matching of cylinder and conrod bearing cap to conrod → Item.

–	Remove conrod bearing cap and withdraw piston and conrod upwards.

Note

If the piston pin is difficult to move, heat the piston to approx. 60°C.

–	Remove circlip from piston pin eye.

–	Drive out piston pin using drift -VW 222 A-.

Installing

Installation is carried out in the reverse order; note the following:

Note

Renew bolts that are tightened with specified tightening angle.

–	Oil running surfaces of bearing shells.

–	Install piston with commercially available piston ring clamp, noting installation position → Fig..

–	Install conrod bearing cap, noting installation position → Item.

–	Installing cylinder head → Chapter.

–	Remove upper part of sump → Chapter.

Specified torques

→ Chapter „Assembly overview - pistons and conrods“

Removing and installing pistons

Assembly overview - pistons and conrods

1 - Bolts Renew Oil threads and contact surface 30 Nm + 90° 2 - Conrod bearing ...

Removing and installing oil spray jets

Special tools and workshop equipment required Socket -T10545- Removing – Remove noi ...

Other materials:

Main beam assist
First read and observe the introductory information and safety warnings Main beam assist (Light Assist) Within the limits of the system, the main beam assist automatically switches the main beam on at speeds of over approximately 60 km/h (37 mph), depending on environmental and traffic con ...

Adhesive sealant
Designation: Adhesive sealer -D 511 500 A2-, grey Adhesive sealer -D 511 510 A2-, black Issued 04.2009 Product description Adhesive sealant -D 511 500 ...

Childproof lock
Fig. 34 In the left rear door: childproof lock Ⓐ switched off, Ⓑ switched on Fig. 35 In the right rear door: childproof lock Ⓐ switched off, Ⓑ switched on First read and observe the introductory information and safety warnings The childproof lock prevents the rear doors from bein ...