VW Golf manuals

Volkswagen Golf Service & Repair Manual: Removing and installing massage control unit -J740-

Volkswagen Golf Service & Repair Manual / General body repairs, interior / Seat frames / Front seats / Removing and installing massage control unit -J740-

Special tools and workshop equipment required
   
   

Removal wedge -3409
Removal wedge -3409

Removing
–  If fitted, remove storage compartment → Chapter.
–  Unclip wiring harness -3- from retainer.
–  To do this, lever off cable retainer -4- using removal wedge -3409-.
–  Release connectors -2- and pull them off.
–  Release massage control unit -J740--1- from retaining tabs -5-.
–  Pull massage control unit -J740--1- out of mountings -arrows-.
Installing
Install in reverse order, but note the following:
–  Renew any damaged cable ties and clips.
–  Route wires in their original positions.
Specified torques
  → Chapter „Assembly overview - front seat“
  → Chapter „Assembly overview - seat pan“
  Assembly overview - storage compartment → Anchor
 

Removing and installing massage control unit -J740-

Removing and installing seat adjustment operating unit -E470-/-E471-
  Note Removal and installation are described for the left vehicle side. Follow same instructions for the right side as appropriate. ...

Rear seats
...

Other materials:

Removing and installing upper transverse link, four-wheel drive
Special tools and workshop equipment required     Torque wrench -V.A.G 1332- Removing –  Loosen wheel bolts. –  ...

Assembly overview – repair kit for headlight housing, does not apply for LED headlights
1 -  Headlight 2 -  Inner retaining tab Removing and installing → Chapter 3 -  Bolt Qty. 1 Specified torque: 2 Nm 4 -  Rear retain ...

Assembly overview - brake caliper (PC57 brakes)
When carrying out repairs, install all parts supplied in repair kit. Use only methylated spirits for cleaning the brake. Apply thin coat of lithium grease -G 052 150 A2- to brake cylinder, piston and seal. 1 -  Dust cap ...

© 2016-2024 Copyright www.vwgolf.org