Volkswagen Golf Service & Repair Manual: Removing and installing -J245-sliding sunroof adjustment control unit
Special tools and workshop equipment
required |
|
|
|
|
|
Torque wrench -V.A.G 1783- |
– |
Remove glass panel
→ Chapter. |
– |
If drive is defective, remove glass panel
→ Chapter. |
– |
Pull self-adhesive insulation -3- off. |
– |
Pull out cover upwards at an angle -arrows-. |
WARNING
Remove or install drive for panorama tilting
sunroof glass panel only when sunroof is closed ("0" position ). |
The requirements for removing and installing drive
are: Engine not running and ignition off, key not in ignition
and door open. |
|
– |
Switch engine and ignition off, remove key and open door. |
l |
This situation must be maintained until drive has been installed. |
– |
Remove bolts -4- and pull off drive for
panorama tilting roof -1-. |
– |
Detach drive connector -5-. |
Note
The bolts for the drive are microencapsulated and must always be
renewed. |
– |
Plug in connector -5- at drive
-1-. |
– |
Check that the clips -2- are correctly
seated. |
– |
Attach drive -1- and tighten bolts
-4-. |
– |
After installation, the key can be inserted in ignition and starter
switch again. |
– |
Then test for proper function. |
– |
Push cover onto assembly frame. |
– |
Attach self-adhesive insulation -3-. |
|
Sliding sunroof adjustment control unit -J245-
→ Chapter |
Special tools and workshop equipment
required
Cartridge gun -V.A.G 1628-
...
Removing
–
Remove glass panel
→ Chapter.
–
If drive is defective, remove glass panel
→ Chapter.
...
Other materials:
Assembly overview - steering rack, right-hand drive
Caution
The following work must not be performed while the universal
joint is separated from the steering rack:
Connect battery.
Switch on ignition.
Turn steering rack.
...
Introduction
This chapter contains information on the following subjects:
→ Attaching the mounts and roof carrier
→ Loading the roof carrier
The roof of the vehicle has been designed for optimum aerodynamic effect. It
is therefore no longer possible to attach conventional roof carrie ...
Overview of fitting locations – controls in centre console
Note
The illustration shows fitting locations for LHD vehicles. Fitting
locations for RHD vehicles are similar.
1 -
Starter button -E378-
Removing and installing
→ Chapter
2 -
Switch mod ...
© 2016-2024 Copyright www.vwgolf.org