Volkswagen Golf Service & Repair Manual: Removing and installing headlight main beam bulb -M30-/-M32- (dual halogen
headlights)
Note
Removal and installation are described for the left side.
Removal and installation on the right side are carried out in
the same way. |
|
|
|
– |
Pull off housing cover -1- in
direction of arrow -A-. |
|
|
|
– |
Turn grip -1- in direction of
arrow -A- until contacts are
disconnected from connector housing -2-. |
– |
Pull out grip -1- in direction
of arrow -B-. |
|
|
|
– |
Pull bulb -2- out of grip
-1-. |
Install in the reverse order of removal, observing the
following: |
Caution
Risk of damage to the headlight. |
Do not touch the glass part of the bulb with bare
fingers. Fingers leave traces of grease on the glass
bulb, which vaporise when the bulb is switched on and
cause the glass bulb to cloud over. |
Wear, for example, clean fabric gloves when
inserting bulbs. |
Make sure the housing cover is correctly seated when
installing. The ingress of water will lead to permanent
damage to the headlight. |
|
– |
Check headlight setting and adjust headlight if necessary
→ Booklet36.1 |
|
|
|
Special tools and workshop equipment
required
Front-end hook -3370-
...
Note
Removal and installation are described for the left side.
Removal and installation on the right side are carried out in
the same way.
...
Other materials:
Assembly tools for single wire seals
The assembly tools serve as a means of sliding the single
wire seals fully into the contact housing without damage and
thereby assure complete sealing between single wire and contact
housing.
Four assembly tools for single wire seals are ...
Assembly overview - dual halogen headlight
1 -
Bulb for side lights/daytime running lights/main beam headlights
The bulb has 3 functions:
Left side light bulb -M1-/right side light bulb -M3-
Left daytime running light bulb -L174-/right daytime running light
bul ...
Checking colour indicator, “2-colour”
WARNING
Danger of injury! Observe warning notices and safety
regulations
→ Chapter!
General information about colour indicator:
The genera ...
© 2016-2024 Copyright www.vwgolf.org