Volkswagen Golf Service & Repair Manual: Removing and installing headlight
Special tools and workshop equipment
required |
|
|
|
Torque wrench -V.A.G 1783- |
|
|
|
– |
Unscrew bolts -3- from front wheel
housing liner. |
– |
Unscrew bolts -1- if present. |
– |
Release bumper -2- from wing and pull
it off in direction of arrow -A-. |
– |
Mask off marked area -3- on
headlight -2-. |
– |
Mask off underside of wing tip -4-. |
– |
Mask off marked area -5- on
bumper -1-. |
|
|
|
– |
Unscrew bolts -3, 5 and 6-. |
– |
Disconnect electrical connector. |
– |
Pull headlight -1- forwards to remove. |
Install in the reverse order of removal, observing the
following: |
– |
Press headlight into bumper guide. |
– |
Ensure uniform gap all around headlight
→ Chapter. |
|
|
|
– |
Insert bumper -1-. When doing
this, ensure that bumper is being guided into mountings
-2- beneath headlight. |
– |
Check headlight setting and adjust headlight if necessary
→ Booklet36.1 |
→ Chapter „Assembly overview - headlight“ |
|
|
|
Adjusting dual halogen headlight |
Adjusting dual halogen headlight
→ Booklet36.1. |
|
|
|
Adjusting gas discharge headlights |
Adjusting gas discharge headlights
→ Booklet36.1. |
|
Adjusting LED headlights
→ Booklet36.1. |
|
Adjusting fog lights
→ Booklet36.1 |
|
|
|
Adjusting auxiliary headlights |
Retrofitted auxiliary headlights of other systems must be
checked and adjusted according to valid guidelines. |
|
|
|
1 -
LED module for daytime running light and side light
Left LED module for daytime running light and side light -L176-
Right LED module fo ...
Special tools and workshop equipment
required
Torque wrench -V.A.G 1783-
...
Other materials:
Schematic diagram - coolant hoses, Golf GTE
Note
Currently, only the auxiliary heater function is available.
At the moment the auxiliary heater is not intended to be
operated as a supplementary heater. In vehicles with a
high-voltage system, the high-voltage heater (PTC) -Z115- is
...
Removing and installing dash panel
Special tools and workshop equipment
required
Torque wrench -V.A.G 1783-
Removing
–
Remove centre console
→ Chapter.
...
Aqua-Premium - application instructions for water-based products
Issued 06.2013
When using water-based products always devote scrupulous
care to the substrate preparations before pretreating with the
materials specifically recommended for use with water-based
products.
Substrate ...
© 2016-2024 Copyright www.vwgolf.org