Volkswagen Golf Service & Repair Manual: Removing and installing front air distribution flap actuation unit, heater
and air conditioning system with electric/manual controls, RHD vehicles
| – |
Remove dash panel central tube
→ General body repairs, interior; Rep. gr.70. |
| – |
Remove air duct for defroster vent
→ Chapter. |
| – |
Unbolt air distribution flap control motor
→ Chapter. |
|
|
|
| – |
Carefully press off actuating lever
-7--arrow-. |
| – |
Carefully press actuating lever -3-
off defroster flap lever -2-. |
| – |
Unscrew bolts -1-,
-4- and -8-. |
| – |
Remove actuation unit -9-
upwards. |
| – |
Installation is carried out in the reverse order. When
installing, note the following: |
 Note
| Check operation of flaps and hinge mechanism before fitting. |
| Make sure levers and shafts are properly fitted in the
mounts. |
|
|
|
| – |
Check that the two gear wheels are correctly aligned. |
| The rectangular tooth -2- must
engage in the gap -3- of the gear
wheel -1-. |
|
|
|
| – |
When fitting actuation unit, actuating lever
-5- must engage in lever
-6- of centre vent flap. |
| → Chapter „Assembly overview - heater and air conditioning unit“ |
| Assembly overview - dash panel central tube
→ General body repairs, interior; Rep. gr.70. |
|
|
|
Removing
–
Remove dash panel
→ General body repairs, interior; Rep. gr.70.
–
Remov ...
Removing
–
Remove dash panel
→ General body repairs, interior; Rep. gr.70.
–
Remov ...
Other materials:
Introduction
This chapter contains information on the following subjects:
→ Displays
→ Operation
The traffic sign recognition system can help the driver check the speed limits
or overtaking restrictions that currently apply.
The traffic signs and additional information recognised ...
Centre armrest
Fig. 51 Front centre armrest
Fig. 52 Folding down the rear centre armrest
First read and observe the introductory information
and safety warnings Adjusting the front centre armrest
To lift, push the centre armrest up gradually in the direction of arrow
.
To lower, pull the centre ar ...
Overview of fitting locations - front control motors, air conditioning system
with electric/manual controls, RHD vehicles
1 -
Temperature flap control motor -V68-
Checking: with vehicle diagnostic tester
Removing and installing
→ Chapter.
Renewing: initiate basic setting using vehicle diagnostic tester.
2 -&nb ...
© 2016-2024 Copyright www.vwgolf.org
Removing and installing front air distribution flap actuation unit, heater
and air conditioning system with electric/manual controls, LHD vehicles
Removing and installing front air distribution flap actuation unit,
Climatronic