Volkswagen Golf Service & Repair Manual: Removing and installing electronics box (E-box)
| – |
With ignition switched off, disconnect earth cable from
battery
→ Chapter. |
| – |
Remove engine control unit and lay to one side with
connectors attached
→ Rep. gr.23. |
| – |
Remove engine control unit and lay to one side with
connectors attached
→ Rep. gr.24. |
| Continuation for all vehicles |
|
|
|
| – |
Press release buttons -arrows-. |
| – |
Remove cover -1- for
electronics box in engine compartment. |
|
|
|
| – |
Release retaining tab -2- using
a screwdriver and pull off front cover -1-
upwards -arrow-. |
|
|
|
| – |
Cut through cable tie (bottom) on wiring harness. |
| – |
Release fasteners -1, 2 and 4--arrow-,
remove fuse holder B -3- and lay to
one side. |
|
|
|
| – |
Unscrew nuts -arrows- and
remove bracket for engine control unit -1-. |
| – |
Release retaining tab -3- and
disengage engine compartment electronics box
-2- from studs. |
| – |
Lift out engine compartment electronics box. |
| Install in the reverse order of removal, observing the
following: |
| → Chapter „Overview of fitting locations – relay carriers, fuse
holders, electronics boxes“ |
| – |
Connect battery
→ Chapter. |
|
|
|
1 -
Battery -A-
Removing and installing
→ Chapter
Disconnecting and connecting
→ Chapter
2 ...
Removing
–
With ignition switched off, disconnect earth cable from
battery
→ Chapter.
...
Other materials:
Removing and installing front ashtray
Removing
–
Remove front ashtray -1-
upwards from centre console -2-.
Installing
Installation is carried out in reverse order.
...
Relay carriers, fuse carriers, electronics box (engine compartment)
1 -
Front cover
For electronics box in engine compartment
2 -
Nut
Specified torque: 9 Nm
3 -
Nut
Specified torque: 9 Nm
4 -
Wire/line
...
Drawers
Fig. 116 Drawer under the front seat
First read and observe the introductory information
and safety warnings A drawer may be located under each of the front seats
.
Opening or closing the drawer
To open, press the button in the drawer grip and open the drawer.
To close, push the dra ...
© 2016-2024 Copyright www.vwgolf.org
Overview of fitting locations – fuse box, battery (vehicles with
high-voltage system)
Removing and installing fuse holder B -SB-