Volkswagen Golf Service & Repair Manual: Removing and installing dash panel cover on driver side
Special tools and workshop equipment
required |
|
|
|
|
|
Torque wrench -V.A.G 1783- |
– |
Remove dash panel end cover on driver side
→ Chapter. |
– |
Remove driver side footwell cover
→ Chapter. |
– |
Remove centre console cover on driver side
→ Chapter. |
– |
Remove storage compartment on driver side
→ Chapter. |
– |
Unscrew bolt -2- at side. |
– |
Unscrew bolt -3- at bottom. |
– |
Remove bolts -4- and
-5- |
– |
Unclip dash panel cover on driver side -1-
from dash panel -arrows- and remove it. |
Note
Before installing, check all fasteners for damage and renew
if necessary. |
Installation is carried out in reverse order. |
|
→ Chapter „Assembly overview - driver side dash panel cover“ |
|
|
|
Removing
–
Open driver side storage compartment -1-
in -direction of arrow-.
–
Release driver side storage compartment -1-
from u ...
Special tools and workshop equipment
required
Removal wedge -3409-
...
Other materials:
Removing and installing drive shaft heat shield
Front-wheel drive:
Component
Specified
torque
Bolts -1-
25 Nm
Four-wheel drive:
...
Brake test
General information
The drive is provided by the test rig.
For the test, ensure for vehicles with a manual gearbox that
the gear lever is in neutral, and for vehicles with an automatic
gearbox that the select ...
Leaks at shock absorbers
Shock absorbers are often replaced because of externally
visible leakage. Inspections on the test rig and in the vehicle
have shown that in the majority of cases this replacement is not
justified.
Slight loss of fluid (“sweating”) at ...
© 2016-2024 Copyright www.vwgolf.org