VW Golf manuals

Volkswagen Golf Service & Repair Manual: Removing and installing bonnet lock

Special tools and workshop equipment required
   
Removing
  Torque wrench -V.A.G 1331-
Torque wrench -V.A.G 1331-

Removing and installing bonnet lock

  Note
If the rear lid does not open, it can be opened in an emergency by reaching through the rear lid trim and actuating the emergency release by hand → Operating Manual.
–  Remove rear lid trim → General body repairs, interior; Rep. gr.70.
–  Detach connector -3- from lid lock -1-.
–  Unscrew bolts -2- and remove rear lid lock -1- from rear lid.

 
Installing
   

Removing and installing bonnet lock

–  Position rear lid lock -1- on rear lid and screw in bolts -2-.
–  Connect connector -3- to rear lid lock -1-.
Before closing rear lid, check function of lid release components.
Specified torques
Adjusting rear lid
Special tools and workshop equipment required         Torque wrench -V.A.G 1331- ...

Removing and installing hinges
Special tools and workshop equipment required     Removing   Torque wre ...

Other materials:

Assembly overview - gas discharge headlight with cornering light and LED daytime running light
1 -  Headlight Removing and installing → Chapter 2 -  Front turn signal bulb Front left turn signal bulb -M5- Front right turn signal bulb -M7- Removing and installi ...

Assembly overview - anti-roll bar, multi-link suspension, four-wheel drive
1 -  Lower transverse link 2 -  Nut Renew after removing 20 Nm +180° 3 -  Coupling rod Removing and installing → Chapter 4 -  ...

Overview of the driver door
Fig. 4 Overview of the controls in the driver door (left-hand drive vehicles) The controls are mirrored for right-hand drive vehicles Key for  : Door release lever   Central locking buttons for locking and unlocking the vehicle –   Switch for adjusting the exterior ...

© 2016-2024 Copyright www.vwgolf.org