Volkswagen Golf Service & Repair Manual: Removing and installing air filter housing
| – |
Lift air cleaner housing -1-
off ball studs. |
| – |
Release hose clips -3- and
-4- and remove air ducts. |
 Note
| If the air filter element is very dirty or wet, particles of
dirt or water may reach the components and falsify the measured
air mass value. This would lead to loss of power, since a
smaller injection quantity is calculated. |
| Always use genuine part for air filter element. |
| A clean air filter housing is essential. |
| Before fitting the air filter housing, the ball pins on the
intake manifold must be moistened with water without additives. |
| Hose unions and air intake pipes and hoses must be free of
oil and grease before installation. |
| Use a silicone-free lubricant when installing air hoses. |
| Secure all hose connections with the same type of hose clips
as original equipment
→ Electronic Parts Catalogue. |
| To prevent malfunctions, cover critical parts of the engine
air intake (air pipes etc.) with a clean cloth when blowing out
the air cleaner housing with compressed air. |
| Observe disposal regulations! |
| – |
Extract salt residues, dirt or leaves from upper or lower
part of air filter housing. |
| – |
Blow out water drain with compressed air. |
| → Chapter „Assembly overview - air filter housing“ |
|
|
|
1 -
Air duct (bottom section)
On lock carrier
2 -
Air duct (top section)
On lock carrier
3 -&n ...
Other materials:
Centre armrest
Fig. 51 Front centre armrest
Fig. 52 Folding down the rear centre armrest
First read and observe the introductory information
and safety warnings Adjusting the front centre armrest
To lift, push the centre armrest up gradually in the direction of arrow
.
To lower, pull the centre ar ...
Checking operation and power supply of fuel pump
Special tools and workshop equipment
required
Removal wedge -3409-
Multimeter e.g. hand-held multimeter -V.A.G 1526E-
...
Removing and installing window regulator
Special tools and workshop equipment
required
Note
Removal and installation are described only for the left
window regulator. Removal and installa ...
© 2016-2024 Copyright www.vwgolf.org
Assembly overview - air filter housing
Intake manifold