Volkswagen Golf Service & Repair Manual: Refrigerant circuit components
Caution
| Non-authorised tools or materials (e.g. leak
inhibitor additive) may cause damage or adversely
influence the system. |
| Only tools and materials approved by the
manufacturer may be used. |
| The use of non-approved tools or materials will
render the warranty void. |
|
| All components of the refrigerant circuit that were
submitted for quality monitoring must always be sealed (use the
original sealing caps from the genuine part). |
| Renew damaged or leaky components of the refrigerant circuit
→ Chapter. |
| The genuine parts (air conditioner compressor, reservoir,
receiver, evaporator and condenser) are charged with nitrogen
before shipment. This filling is being gradually discontinued.
Therefore, when the sealing plugs are unscrewed from the genuine
part little or no pressure equalisation is noticeable. |
|
|
|
On the high-pressure side, there are the condenser, the
receiver and the restrictor or expansion valve that acts as the
separation between the high-pressure fluid and ...
Other materials:
Professional cleaning cloth -VAS 6006
Designation:
Professional cleaning cloth -VAS 6006-
Product description:
The cloth is suitable for cleaning dust and micro dust from
dry surfaces. It has anti-static properties when used to clean
...
Renewing bonded rubber bush for axle beam
Special tools and workshop equipment required
Tensioning strap -T10038-
Assembly tool -T10254-
Assembly tool -T10495-
Torque wrench -V.A.G 1332-
Engine and gearbox jack -V.A.G 1383 A--2-
w ...
Noises from shock absorbers
Shock absorbers are often replaced because of noises
(rumbling, etc.) experienced by the customer. Inspections on the
test rig and in the vehicle have shown that in approx. 70 % of
these cases there is no case for complaint. The replacement was
not justi ...
© 2016-2024 Copyright www.vwgolf.org
Distribution of the refrigerant circuit components and their influence on
the high-pressure and low-pressure sides