Volkswagen Golf Service & Repair Manual: Overview of fitting locations - fuel supply system, Golf Variant
Note
Fuel lines are secured with O-type clips. These O-type clips
must always be renewed every time they are removed. |
Start engine if fuel tank was empty. Then start the
auxiliary heater repeatedly until the heater does not switch off
by itself. |
Observe the rules for cleanliness when doing all work on the
fuel supply system
→ Chapter. |
Always observe the safety precautions when working on the
fuel supply system
→ Chapter. |
|
|
|
1 - |
Fuel line to metering pump -V54- |
With auxiliary heater control unit -J364-. |
Location: behind front bumper cover on right |
Removing and installing
→ Chapter |
3 - |
Quick-release coupling of fuel line |
4 - |
Quick-release coupling of fuel line |
The metering pump -V54- is located on the fuel tank. |
Removing and installing
→ Chapter |
Testing quantity of fuel delivered
→ Chapter. |
Fuel delivery unit can be found on right under bench seat. |
With fuel gauge sender -G- |
Removing and installing
→ Rep. gr.20 |
Note
Fuel lines are secured with O-type clips. These O-type clips
must always be renewed every time they are removed.
Star ...
Note
Check fuel delivery rate as described in “Guided Fault
Finding” function, vehicle diagnostic tester in “Guided Fault
Finding” mode.
...
Other materials:
Wiring open circuit with one repair position
Repair position with single crimp connector
–
Place the wire to be repaired to one side (about 20 cm
either side of the repair position).
–
If necessary, unbind the wir ...
Water content
Only very small amounts of water are soluble in liquid
refrigerant. On the other hand, refrigerant vapour and water
vapour mix in any proportion.
Any water present in the refrigerant circuit will be carried
along as droplets. The dessica ...
Assembly overview - selector mechanism, manufacturer ZF
1 -
Handle with selector cover
Do not remove handle without reason. Emergency release from position
P
→ Chapter
Removing and installing
→ Chapter
Moving push button to installation positio ...
© 2016-2024 Copyright www.vwgolf.org