Volkswagen Golf Service & Repair Manual: Connecting brake lines to hydraulic unit, RHD vehicles
1 - |
From hydraulic unit to rear left brake caliper. |
- |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
2 - |
From hydraulic unit to front right brake caliper. |
- |
Identification: Ш 5.25 mm and flare nut with short thread M
12 x 1 |
3 - |
From hydraulic unit to front left brake caliper. |
- |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
4 - |
From hydraulic unit to rear right brake caliper |
- |
Identification: Ш 5.25 mm and flare nut with short thread M
12 x 1 |
A - |
From hydraulic unit to primary piston circuit of brake
master cylinder. |
- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
B - |
Hydraulic unit to brake system pressure accumulator -VX70- |
- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
|
|
|
On brake master cylinder: |
|
|
|
On brake system pressure accumulator -VX70-: |
A - |
Brake system pressure accumulator -VX70- to hydraulic unit |
- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
B - |
Brake system pressure accumulator -VX70- to secondary piston
circuit of brake master cylinder |
- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
|
|
|
On hydraulic unit:
1 -
From hydraulic unit to rear right brake caliper
-
Identification: Ш 5.25&nb ...
Special tools and workshop equipment
required
ESD workplace -VAS 6613-
Torx bit T25
I ...
Other materials:
Load-through hatch
Fig. 97 In the rear seat backrest: opening
the load-through hatch
Fig. 98 In the luggage compartment: opening
the load-through hatch
First read and observe the introductory information
and safety warnings A load-through hatch is located on the rear bench seat
behind the centre armrest. ...
Removing and installing brake pads, FS III front brake
Special tools and workshop equipment
required
Torque wrench -V.A.G 1331-
Piston resetting appliance -T10145-
...
Overview - rear axle, multi-link suspension
I -
→ Chapter „Subframe“
II -
→ Chapter „Anti-roll bar“
III -
→ Chapter „Suspension link, track rod“
IV&n ...
© 2016-2024 Copyright www.vwgolf.org