Volkswagen Golf Service & Repair Manual: Checking exhaust system for leaks
| – |
Start engine and run at idling speed. |
| – |
Seal end exhaust pipes with cloths or plugs, for example,
for the duration of the leakage test. |
| – |
Check (by listening) points of connection between exhaust
manifold and the cylinder head, between turbocharger and front
exhaust pipe etc. to make sure there are no leaks. |
| – |
Rectify any leaks that are found. |
|
|
|
Procedure
The exhaust system must be aligned when cold.
Note
The -arrow- points forwards.
...
Other materials:
General repair instructions
–
→ Chapter „Safety precautions when working on high-voltage
system“ Comply with notes.
–
Read self-diagnosis of auxiliary heater using vehicle
diagnostic tester.
–
...
Removing and installing rain and light sensor, vehicles without front camera
for driver assist systems
Note
The rain and light sensor has a silicon layer (coupling pad)
which forms the contact surface to the windscreen.
The rain and light sensor has been designed so that it can
be used again. A prerequisite for re-use ...
Exterior mirrors
Fig. 94 In the driver door: rotary knob
for the exterior mirrors
First read and observe the introductory information
and safety warnings
When the ignition is switched on, turn the rotary knob
to the desired position:
Fold exterior
mirr ...
© 2016-2024 Copyright www.vwgolf.org
Aligning exhaust system free of tension
Emission control