Volkswagen Golf Service & Repair Manual: Assembly overview - wing

Volkswagen Golf Service & Repair Manual / General body repairs, exterior / Body front / Wing / Assembly overview - wing

Volkswagen R GmbH, optional equipment, “R Line” and “R”

Note

Only the left side is shown. The right side is similar.

Assembly overview - wing

1 -

Wing

Removing and installing → Chapter

2 -

Bolt

Qty. 2, A-pillar
6.0 Nm

3 -

Bolt

Qty. 2, side member
6.0 Nm

4 -	Insulation for rib section

Inserted between wing and A-pillar.

5 -	Wing insulation

Inserted between wing and upper wheel housing longitudinal member

6 -	Hexagon nut

Qty. 2
2.0 Nm

7 -	Guide bracket

Removing
Remove front bumper cover → Chapter
Unscrew hexagon nut -6-
Different versions, allocation → Electronic Parts Catalogue “ETKA”

8 -	Centre hex stud

Qty. 2, wing bracket
6.0 Nm

9 -	Wing bracket

Removing and installing → Chapter

10 -

Bolt

Qty. 3, wing connection piece
6.0 Nm

11 -	Deformable element

At front and rear → Chapter

Wing

...

Assembly overview - deformable element

1 - Front deformable element 2 - Bolt 6.0 Nm 3 - Rear deformable element 4 - Bolt ...

Other materials:

Introduction
This chapter contains information on the following subjects: → Contents of the breakdown set → Preparation → Sealing and inflating tyres → Test after driving for 10 minutes You can use the breakdown set (tyre mobility set) to safely seal any tyre damage cause ...

Overview of fitting locations
Overview of fitting locations - ABS/ESP 1 - ABS control unit -J104- Installation location: on hydraulic unit, on passenger side of engine compartment. Do not separate connector before successfully completing self-diagn ...

Classification of extraction and charging devices in groups
Group 3: Portable extraction and charging devices linking the air conditioning system to a fixed compressed gas container. The fixed compressed gas container is charged with refrigerant or refrigerant/oil mixture. The po ...