VW Golf manuals

Volkswagen Golf Service & Repair Manual: Assembly overview - steering rack, right-hand drive

Volkswagen Golf Service & Repair Manual / Running gear, axles, steering / Steering / Steering rack / Assembly overview - steering rack, right-hand drive

  Caution
The following work must not be performed while the universal joint is separated from the steering rack:
Connect battery.
Switch on ignition.
Turn steering rack.
Turn steering column.
Not adhering to these instructions will result in irreparable damage.

Assembly overview - steering rack, right-hand drive

1 -  Wiring
2 -  Fastener
3 -  Steering rack
Removing and installing → Chapter
Different versions possible. Refer to → Electronic Parts Catalogue “ETKA”
With power steering control unit -J500-
Can be tested in “Guided fault finding” using → Vehicle diagnostic tester
4 -  Left wheel bearing housing
5 -  Nut
Renew after removing
20 Nm +90°
6 -  Subframe
7 -  Bolt
Renew after removing
70 Nm +90°
8 -  Right wheel bearing housing
9 -  Heat shield
Different versions possible depending on engine version. Refer to → Electronic Parts Catalogue “ETKA”
10 -  Bolt
Either qty. 3 or qty. 4 are fitted depending on engine version. Refer to → Electronic Parts Catalogue “ETKA”
8 Nm
Assembly overview - steering rack, left-hand drive
  Caution The following work must not be performed while the universal joint is separated from the steering rack: Connect battery ...

Removing and installing steering rack, LHD vehicles, except for e-Golf
Special tools and workshop equipment required Ball joint puller -T10187- Torque wrench -V.A.G 1331- Torque wrench -V.A.G 1332- ...

Other materials:

Assembly overview - assembly mountings
1 -  Bolt Renew Tightening sequence → Fig. 2 -  Engine support Specified torque and tightening sequence → Fig. 3 -  Engine mounting ...

Extraction and charging valve, high-pressure side
  Note Torque wrench -V.A.G 1783- with 1/4" ratchet adapter -VAS 6234- Appropriate insert -T10364- to remove valve core → Fig. 1 -  Base with external or internal thread ...

Removing and installing brake pads, front brakes
Special tools and workshop equipment required     Torque wrench -V.A.G 1331-   Piston resetting appliance -T 10145- ...

© 2016-2024 Copyright www.vwgolf.org