Volkswagen Golf Service & Repair Manual: Assembly overview - fuel delivery unit/fuel gauge sender, vehicles with
front-wheel drive
With fuel system pressurisation pump -G6-. |
With integrated fuel filter; cannot be renewed individually. |
With integrated pressure limiting valve; cannot be renewed
individually. |
Check electric fuel pump → Vehicle
diagnostic tester. |
Removing and installing
→ Chapter. |
Remove and tighten with wrench -T10202-. |
4 - |
Fuel pump control unit -J538- |
Not fitted in vehicles with engine code CWVA |
Check in Guided fault finding
→ Vehicle diagnostic tester |
Removing and installing
→ Chapter |
For fuel pump control unit -J538-. |
Ensure proper engagement; check if connector is engaged correctly by
pulling. |
For fuel system pressurisation pump -G6- and fuel gauge sender -G-. |
Ensure proper engagement; check if connector is engaged correctly by
pulling. |
To pull off, press release button on connection. |
Plug-in connectors must engage »audibly«
when joined. |
Ensure plug-in connector is secured properly by pulling it. |
Disconnect plug-in connectors
→ Chapter |
8 - |
Fuel gauge sender -G- |
Checking → Vehicle
diagnostic tester |
Removing and installing
→ Chapter. |
Installation position of fuel delivery unit |
The arrow -3- on the fuel tank
must line up with the mark -2- on
the sealing flange -1-. |
|
|
|
Fuel lines on fuel delivery unit |
2 - |
Fuel line to metering pump -V54- |
|
|
|
1 -
Fuel pump control unit -J538-
Check with → Vehicle
diagnostic tester
Removing and installing
→ Chapter
...
Other materials:
Bringing air conditioning system into service after charging
Note
If the air conditioner compressor was removed, the V-belt
pulley /freewheel must be turned by hand approx. 10 times prior
to initial operation. This prevents any damage occurring from a
fluid hammer in the air conditioner compressor when th ...
Overview of fitting locations - fuel supply system, Golf Variant
Note
Fuel lines are secured with O-type clips. These O-type clips
must always be renewed every time they are removed.
Start engine if fuel tank was empty. Then start the
auxiliary heater repeatedly until the heater d ...
Towing attachment type plate
The trailer load and drawbar load details on the type plate
of the towing attachment are test figures for the device. The
approved details for the relevant vehicle could be below the
trailer load and drawbar load specifications of the trailer.
Figures ca ...
© 2016-2024 Copyright www.vwgolf.org