Volkswagen Golf Service & Repair Manual: Assembly overview - fuel delivery unit/fuel gauge sender, vehicles with
auxiliary heater
| With fuel system pressurisation pump -G6-. |
| With integrated fuel filter; fuel filter cannot be renewed
separately |
| Carrying out electrical test of fuel pump in
Guided fault finding mode → Vehicle
diagnostic tester |
| Removing and installing
→ Chapter |
| After installing, fill vehicle with at least 5 litres of fuel. |
| Secure hose connection with the hose clips corresponding to original
equipment. |
| Secure hose connection with the hose clips corresponding to original
equipment. |
| Removing and installing
→ Chapter |
1 -
Fuel pump control unit -J538-
Check with → Vehicle
diagnostic tester
Removing and installing
→ Chapter
...
Special tools and workshop equipment
required
Wrench -T10202-
...
Other materials:
Seat belt routing
Fig. 66 Correct seat belt routing and head
restraint adjustment
Fig. 67 Correct seat belt routing during
pregnancy
First read and observe the introductory information
and safety warnings Seat belts only provide an optimum level of protection
during an accident when they are routed corr ...
Removing and installing tank pressure sensor -G400
Removing
Note
The tank pressure sensor -G400- is located in the pressure
regulating valve on the activated charcoal filter
→ Chapter.
–
Remove activated charcoal filter
→ ...
2-pack thinner
Designation:
2-pack thinner -LVE 009 001 A5-
2-pack thinner, slow-drying -LVM 009 300 A2-
2-pack thinner plus -LHA 014 000 A5-
2-pack thinner, special -LVM 009 20 ...
© 2016-2024 Copyright www.vwgolf.org
Assembly overview - fuel delivery unit/fuel gauge sender, vehicles with
four-wheel drive
Removing and installing fuel delivery unit/fuel gauge sender, vehicles with
front-wheel drive