Volkswagen Golf Service & Repair Manual: Assembly overview - dual halogen headlight

Volkswagen Golf Service & Repair Manual / Electrical system / Lights, lamps, switches outside / Headlight / Assembly overview - dual halogen headlight

Assembly overview - dual halogen headlight

1 -	Bulb for side lights/daytime running lights/main beam headlights

The bulb has 3 functions:

Left side light bulb -M1-/right side light bulb -M3-

Left daytime running light bulb -L174-/right daytime running light bulb -L175-

Left headlight main beam bulb -M30-/right headlight main beam bulb -M32-

Removing and installing → Chapter

2 -

Grip

For bulb for daytime running lights/main beam headlights.

3 -	Housing cover

4 -	Housing cover

5 -	Headlight range control motor

Left headlight range control motor -V48-

Right headlight range control motor -V49-

Removing and installing → Chapter

6 -	Housing cover

7 -	Housing cover

8 -	Bulb holder

For headlight dipped beam bulb.

9 -	Headlight dipped beam bulb

Left headlight dipped beam bulb -M29-

Right headlight dipped beam bulb -M31-

Removing and installing → Chapter

10 -

Bolt

For securing on upper longitudinal member.

Specified torque: 8 Nm

11 -	Adjustment element

12 -

Bolt

Only needs to be loosened.

For securing on headlight holder.

Specified torque: 4 Nm

13 -	Compensation element

14 -	Snap-on nut

15 -

Bolt

For securing on bumper guide.

Specified torque: 4 Nm

16 -

Headlight

Removing and installing → Chapter

17 -

Stop bolt

For aligning headlight parallel to bonnet edge.

18 -	Banjo bolt

For height adjustment of headlight

19 -

Bolt

For securing on lock carrier.

Specified torque: 4 Nm

20 -	Front turn signal bulb

Front left turn signal bulb -M5-

Front right turn signal bulb -M7-

Removing and installing → Chapter

21 -

Grip

For front turn signal bulb

Headlight

...

Assembly overview - gas discharge headlight

1 - Headlight Removing and installing → Chapter 2 - Front turn signal bulb Front left turn signal ...

Other materials:

Connecting brake lines to hydraulic unit, LHD vehicles
On hydraulic unit: 1 - From hydraulic unit to rear right brake caliper - Identification: Ш 5.25 mm and flare nut with short thread M 12 x 1 2 - From ...

Undulations
Radial depressions are slight concavities in the tyre sidewall. They run from the bead towards the shoulder of the tyre. These parts appear in the figure → Fig.. The cause is the accumulation of material ...

Checking fuel pressure, engine code CWVA
Special tools and workshop equipment required Removal wedge -3409- Pressure tester -VAS 6550- Connector cable -VAS 6550/3-3- Connector cable -VAS 6550/3-4- Vehicle diagnostic tester ...