Volkswagen Golf Service & Repair Manual: Assembly overview - dash panel
| 1 - | Side defroster vent |
- Left and right
- Removing and installing → Chapter
| 2 - | Rubber buffer |
- Qty. 2
- Slide onto dash panel mountings on lower windscreen frame
| 3 - | Bolt |
- 1.5 Nm
| 4 - | Sunlight penetration photosensor -G107- |
- Removing and installing → Heating, air conditioning; Rep. gr.87
| 5 - | Dash panel |
- Removing and installing → Chapter
| 6 - | Trim panel for dash panel |
- Allocation → Electronic Parts Catalogue
- Removing and installing → Chapter
| 7 - | Centre vent with trim for display unit for front information display and operating unit control unit -J685- |
Note| Always remove trim for display unit for front information display and operating unit control unit -J685- and centre vent together as one unit. |
- Removing and installing → Chapter
| 8 - | Dash panel insert trim |
- Removing and installing → Chapter
| 9 - | Rotary light switch -EX1- |
- Removing and installing → Electrical system; Rep. gr.96
| 10 - | Light switch trim |
- Removing and installing → Chapter
| 11 - | Side vent |
- Left and right
- Removing and installing → Chapter
Dash panel
...
Removing and installing dash panel end cover
Note
Removal and installation is described for the dash panel
end cover on driver side. Follow same instructions for the front
passenger side as approp ...
Other materials:
Checking radial and lateral runout on wheels and tyres with tyre gauge
Checking lateral run-out
–
Preload tyre gauge approx. 2 mm.
–
Fit tyre gauge to side wall of tyre.
–
Turn wheel slowly.
...
Removing and installing gas strut
Removing
Note
The rear lid must be supported when a gas strut is removed. One gas
strut alone cannot support an open rear lid.
–
Open rear lid and brace it open.
...
Run-flat tyres, repair work
WARNING
Tyres with run-flat properties must be replaced
after they have been run deflated.
Adhere to the special assembly instructions
→ Chapter.
...
