Volkswagen Golf Service & Repair Manual: Assembly overview - control unit and hydraulic unit, RHD vehicles
1 - |
Brake servo and brake master cylinder |
Assembly overview
→ Chapter. |
Checking brake servo → Vehicle
diagnostic tester |
Removing and installing
→ Chapter |
Removing and installing brake master cylinder
→ Chapter. |
2 - |
ABS hydraulic unit -N55- with ABS control unit -J104- |
Fitting location overview
→ Chapter |
Assembly overview
→ Chapter. |
Removing and installing
→ Chapter |
Separating ABS control unit -J104- from ABS hydraulic unit -N55-
→ Chapter |
Attaching ABS control unit -J104- to ABS hydraulic unit -N55-
→ Chapter |
Connecting brake line
→ Chapter |
To rear right brake caliper |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
Repairing brake lines
→ Chapter |
To front left brake caliper. |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
Repairing brake lines
→ Chapter |
To front right brake caliper |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
Repairing brake lines
→ Chapter |
To rear left brake caliper |
Identification: Ш 5.25 mm and flare nut with thread M 10 x 1 |
Repairing brake lines
→ Chapter |
Check for secure seating after installing |
Ensure that rubber dampers of retainer are not pressed out of
bracket when installing. After installation, check that the ABS
hydraulic unit -N55- is firmly seated, or malfunction can occur. |
13 - |
Brake system pressure accumulator -VX70- |
Assembly overview
→ Chapter. |
Removing and installing
→ Chapter |
Secondary piston circuit of brake master cylinder to brake system
pressure accumulator -VX70- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
Repairing brake lines
→ Chapter |
From primary piston circuit of brake master cylinder to hydraulic
unit. |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
Repairing brake lines
→ Chapter |
From brake system pressure accumulator -VX70- to ABS hydraulic unit
-N55- |
Identification: Ш 6 mm and flare nut with thread M 12 x 1 |
Repairing brake lines
→ Chapter |
1 -
Brake line
From primary piston circuit of brake master cylinder to hydraulic
unit.
Identification: Ш 6 mm and flare nut with ...
Special tools and workshop equipment required
Torque wrench -V.A.G 1331-
Torque wrench -V.A.G 1410-
Brake pedal depressor -V.A.G 1869/2- ...
Other materials:
Recycling and scrapping end-of-life vehicles
First read and observe the introductory information
and safety warnings Recycling end-of-life vehicles
Volkswagen has already made provision for you to recycle your vehicle in an environmentally
responsible manner. The recycling system operating in many European countries will
take back you ...
Driving in a fuel-efficient manner
Fig. 145 Fuel consumption in litres per
100 km at two different outside temperatures
First read and observe the introductory information
and safety warnings By adopting an economical driving style and anticipating
the traffic situation ahead, you can easily reduce fuel consumption by 10-15 ...
Introduction
This chapter contains information on the following subjects:
→ Types of front passenger front airbag system
→ Indicator lamp
→ Description and function of the airbags
→ Front airbags
→ Switching the front passenger front airbag on and of ...
© 2016-2024 Copyright www.vwgolf.org