Volkswagen Golf Service & Repair Manual: Assembly overview - brake caliper (PC57 brakes)
When carrying out repairs, install all parts supplied in repair kit. |
Use only methylated spirits for cleaning the brake. |
Apply thin coat of lithium grease -G 052 150 A2- to brake cylinder,
piston and seal. |
Before screwing in, grease thread with thin coat of lithium grease
-G 052 150 A2- |
Renew after each removal. |
Insert into brake carrier and guide pin groove; grease groove
beforehand, use repair kit grease pack. |
Supplied as preassembled replacement part with greased guide pins
and protective caps. |
If protective caps or guide pins are damaged, install repair kit.
Use lubricant sachet supplied to lubricate guide pins. |
Removing and installing
→ Chapter |
When inserting piston, take care not to damage protective cap |
Removing and installing
→ Chapter |
Apply thin coat of assembly paste G 052 150 A2 to piston before
installing. |
Removing and installing
→ Chapter |
When carrying out repairs, install all parts supplied in repair kit.
Use only methylated spirits for cleaning the brake.
Apply thin coat of lithium grease -G 0 ...
Special tools and workshop equipment
required
Removal wedge -3409-
...
Other materials:
Checking and refilling the windscreen washer fluid level
Fig. 91 In the engine compartment: cap
of washer fluid reservoir
First read and observe the introductory information
and safety warnings The windscreen washer fluid level should be checked regularly
and topped up as necessary.
Open the bonnet .
The washer fluid reservoir is ...
An economic driving style
First read and observe the introductory information
and safety warnings Changing gear earlier
In principle, the highest gear is always the most economical gear. A rule of
thumb for most vehicles: at a speed of 30 km/h (18 mph) drive in 3rd gear, at 40
km/h (25 mph) in 4th gear and at 50 km/ ...
Temporarily switch off the area monitoring system (Front Assist) in the following
situations
First read and observe the introductory information
and safety warnings The area monitoring system (Front Assist) should be switched
off in the following situations due to system limitations :
If the vehicle is being towed.
If the vehicle is on a rolling road test bed.
If t ...
© 2016-2024 Copyright www.vwgolf.org