Volkswagen Golf Service & Repair Manual: Air duct
| Assembly overview - air duct and air
distribution in passenger compartment |
| The assembly overview for air duct and air distribution is
identical with the respective assembly overview for vehicles
with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing driver side
footwell vents |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing front passenger
side footwell vents |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing rear footwell vent |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
| Removing and installing fresh air intake |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing cover for fresh
air intake |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing air intake duct |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Checking exhaust ventilation for passenger
compartment |
| Checking is the same as for a vehicle with air conditioning
system
→ Chapter. |
|
|
|
| Removing and installing exhaust
ventilation for passenger compartment |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing air duct for
defroster vent |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
| Removing and installing air duct for
centre dash panel vent |
| Removal and installation are identical with procedure for
vehicles with air conditioning system
→ Chapter. |
|
|
|
It is not necessary to extract the refrigerant and to remove
or disassemble the expansion valve and the evaporator. Further
procedure is identical with procedure for vehicles wi ...
Overview of control and display unit
1 -
Heated driver seat regulator
Optional
Seat heater has 3 heat settings. Current setting is shown b ...
Other materials:
Assembly overview - cover and padding for backrest
1 -
Upholstery clip
For attaching backrest cover to backrest padding
Renew after removal
When installing, fit in same location using upholstery clip pliers
-V.A.G 1634
2 -
Beading strip
Sewn to backrest cover
Seats with th ...
Recycling and refuse law
Note
The laws and regulations listed below are valid in the
Federal Republic of Germany. Other or additional laws and
regulations may apply in other countries.
Sources in other countries may be obtained from the
...
General repair instructions
–
→ Chapter „Safety precautions when working on high-voltage
system“ Comply with notes.
–
Read self-diagnosis of auxiliary heater using vehicle
diagnostic tester.
–
...
© 2016-2025 Copyright www.vwgolf.org
Dismantling and assembling heater unit
Operating and display unit