Volkswagen Golf Service & Repair Manual: Additional safety instructions for curtain airbag
Inspect trims for damage prior to installing them. |
|
Always renew damaged pillar trims; never repair. |
|
Ensure proper seating of trims when installing them. |
|
When performing repair work behind the curtain airbag,
always remove the entire module. |
|
To prevent any potential damage during removal and
installation, curtain airbags must be handled with extreme
caution. |
|
Place removed curtain airbag modules in packaging or on a
clean, flat surface on a cover. |
|
After body repairs in vicinity of curtain airbag, check body
for weld spray droplets, deformations and areas of chafing
(compare with opposite side if necessary). |
|
Until the gas generator is screwed in place, you must always
hold it firmly by hand when handling (transportation, removal
and installation etc.). |
|
Never twist, kink, throw, shake, pull, hang, squeeze, press,
pinch or clamp any curtain airbag modules. |
|
Folding is acceptable as long as no damage is caused (in
particular to the protective sleeve). |
|
|
|
Under no circumstances may seat covers be fitted which have
not been specifically approved for use on Volkswagen seats with
side airbags.
  ...
The side airbag crash sensors respond to changes in pressure
and must therefore be treated with particular caution. Observe
the following:
&nbs ...
Other materials:
Cavity sealing, body at front and centre
Cavity sealing, door of 2-door
Illustration shows left side. The right side is the mirror image.
Note
The indicated areas have been treated with cavity sealant and must
be resealed following repairs.
...
Removing and installing aerial amplifier for mobile telephone -R86-
Removing
–
Switch off ignition and all electrical consumers, and remove
ignition key.
–
Remove luggage compartment side trim panel (right-side) just
enough so that the aerial amplifier for mob ...
Rules for cleanliness
When working on the fuel supply and injection system,
observe the following “5 rules” for cleanliness:
Thoroughly clean all unions and surrounding areas before
disconnecting.
Place removed parts on a clea ...
© 2016-2024 Copyright www.vwgolf.org